Volume 6, Issue 5, September 2018, Page: 107-120
The Effect of Graphene/TIO2 Nanomaterials on Photocatalytic Performance for Industrial Wastewater Treatment
Abd El-Aziz Hassanin Konsowa, Department of Chemical Engineering, Alexandria University, Alexandria, Egypt
Yehia Abd El-Qadeer EL-Taweel, Department of Chemical Engineering, Alexandria University, Alexandria, Egypt
Shahinaz Ibrahim Abogaliel, Department of Chemical Engineering, Alexandria University, Alexandria, Egypt
Received: Sep. 5, 2018;       Accepted: Oct. 8, 2018;       Published: Nov. 6, 2018
DOI: 10.11648/j.ajche.20180605.15      View  89      Downloads  5
Abstract
The aim of the present work is to combine TiO2/Graphene to increase photo-catalytic activity and obtain efficient removal of direct red 23 azo dye without difficult synthesis. Many operating variables which affect the process and some design aspects were studied. Reactor geometry is the main design parameter where slurry rectangular reactor and bubble column were compared with respect to hydrodynamic regimes, overall degradation efficiency and applicability in industrial scale. The removal rate was found to increase with increase in TiO2 concentration, approaching a limiting value at catalyst loads of 3g/L. For rectangular reactor only 0.005g/L of rGO able to enhance the activity of photo-catalysis. However, the optimum concentration of rGO is decreased in the bubble column reactor to be 0.001g/L. In both reactor systems, photocatalytic activity increase significantly by decreasing wavelength of the irradiated lamp from 365 nm to 254 nm. Also, results show the ability of bubble column reactor to treat high concentrations of dye up to 200 ppm. That makes it suitable to be integrated with biological system to convert non-biodegradable contaminates into biodegradable organics. That reduces the operating cost of the process and makes it more applicable in industrial scale. Rectangular reactor has the ability to be modified to use sunlight instead of artificial lamps because of high surface exposed to sunlight. In general the performance of bubble column reactor was better than rectangular reactor because it has excellent mass transfer characteristics, which enhance the efficiency of the process.
Keywords
Wastewater Treatment, Photocatalysis, Nanomaterials, Slurry Bubble Column Reactor
To cite this article
Abd El-Aziz Hassanin Konsowa, Yehia Abd El-Qadeer EL-Taweel, Shahinaz Ibrahim Abogaliel, The Effect of Graphene/TIO2 Nanomaterials on Photocatalytic Performance for Industrial Wastewater Treatment, American Journal of Chemical Engineering. Vol. 6, No. 5, 2018, pp. 107-120. doi: 10.11648/j.ajche.20180605.15
Copyright
Copyright © 2018 Authors retain the copyright of this article.
This article is an open access article distributed under the Creative Commons Attribution License (http://creativecommons.org/licenses/by/4.0/) which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.
Reference
[1]
M. R. Sohrabi, M. Ghavamiphotocatalytic Degradation Of Direct Red 23 Dye Using UV/TiO2: Effect Of Operational Parameters, Journal Of Hazardous Materials 153 (2008) 1235–1239.
[2]
N. Sobana, K. Selvam, M. Swaminathan, Optimization Of Photocatalytic Degradation Conditions Of Direct Red 23 Using Nano-Ag Doped TiO2, Separation And Purification Technology 62 (2008) 648–653.
[3]
Haidong Liao, Sol-Gel Synthesis And Photocatalytic Characterization Of Immobilized TiO2 Films, Licentiate Thesis In Chemistry Stockholm, Sweden 2009.
[4]
Bill Grote, Application of Advanced Oxidation Processes (AOP) In Water Treatment, Skillstech Australia, 2012.
[5]
Pap Zsolt, Synthesis, Morpho-Structural Characterization and Environmental Application Of Titania Photocatalysts Obtained By Rapid Crystallization, Phd Thesis, University Of Szeged, Babes-Bolyai University 2011.
[6]
Rowan Leary, Aidan Westwood, Carbonaceous Nanomaterials for the Enhancement of TiO2 Photocatalysis, CARBON49 (2011) 741–772.
[7]
Ying Yu, Jimmy C. Yu, Cho-Yin Chan, Yan-Ke Che, Jin-Cai Zhao, Lu Ding, Wei-Kun Ge, Po-Keung Wong, Enhancement Of Adsorption And Photocatalytic Activity of TiO2 By Using Carbon Nanotubes For The Treatment of Azo Dye, Applied Catalysis B: Environmental 61 (2005) 1–11.
[8]
Wenguang Wang, Jiaguo Yu, Quanjun Xiang, Bei Cheng, Enhanced Photocatalytic Activity Of Hierarchical Macro/Mesoporous TiO2–Graphene Composites For Photodegradation Of Acetone In Air, Applied Catalysis B: Environmental 119– 120 (2012) 109– 116.
[9]
K. S. Novoselov, A. K. Geim, S. V. Morozov, D. Jiang, Y. Zhang, S. V. Dubonos, I. V. Grigorieva, A. A. Firsov, Electric field effect in atomically thin carbon films, Science 306 (2004) 666–669.
[10]
Zhai Qianqian, Bo Tang, Hu Guoxin, High Photoactive And Visible-Light Responsive Graphene/Titanate Nanotubes Photocatalysts: Preparation And Characterization, Journal Of Hazardous Materials 198 (2011) 78– 86.
[11]
N. R. Khalid, E. Ahmed, Zhanglian Hong, Yuewei Zhang, M. Ahmad, Nitrogen Doped TiO2 Nanoparticles Decorated On Graphene Sheets For Photocatalysis Applications, Current Applied Physics Xxx (2012) 1-8.
[12]
N. Bouazza, M. Ouzzine, M. A. Lillo-Ro ´Denas, D. Eder, A. Linares-Solano, TiO2 Nanotubes And CNT– TiO2 hybrid Materials For The Photocatalytic Oxidation of Propene at Low Concentration, Applied Catalysis B: Environmental 92 (2009) 377–383.
[13]
Tayyaba Muhammad Akram, Nasir Ahmad, Irfan Ahmad Shaikh, Photocatalytic Degradation of Synthetic Textile Effluent by Modified Sol-Gel, Synthesized Mobilized and Immobilized TiO2, and Ag-doped TiO2, Pol. J. Environ. Stud. Vol. 25, No. 4 (2016), 1391-1402.
[14]
Shaohua Wang, Shaoqi Zhou, Photodegradation of Methyl Orange By Photocatalyst of Cnts/P- TiO2 under Uv and Visible-Light Irradiation, Journal Of Hazardous Materials185 (2011) 77–85.
[15]
Hongtao Yu, Xie Quan, Shuo Chen, Huimin Zhao, Yaobin Zhang, TiO2–Carbon Nanotube Heterojunction Arrays With A Controllable Thickness of TiO2 Layer And Their First Application In Photocatalysis, Journal Of Photochemistry And Photobiology A: Chemistry 200 (2008) 301–306.
[16]
Chang Hyo Kim, Bo-Hye Kim, Kap Seung Yang, TiO2 Nanoparticles Loaded On Graphene/Carbon Composite Nanofibers By Electrospinning For Increased Photocatalysis, CARBON50 (2012) 2472–2481.
[17]
Guodong Jiang, Zhifen Lin, Lihua Zhu, Yaobin Ding, Heqing Tang, Preparation And Photoelectrocatalytic Properties of Titania/Carbon Nanotube Composite Films, CARBON48 (2010) 3369–3375.
[18]
Aisien Felix, Amenaghawon Andrew, Assogba Mededode, Heterogeneous Photocatalytic Degradation of Naphthalene using Periwinkle Shell Ash: Effect of Operating Variables, Kinetic and Isotherm Study, South African Journal of Chemical Engineering, vol. 19, 2014, no. 1, pp 31-45.
[19]
Luisa M. Pastrana-Martínez, Sergio Morales-Torresa, Vlassis Likodimos, José L. Figueiredo, Joaquim L. Faria, Polycarpos Falaras, Adrián M. T. Silva, Advanced Nanostructured Photocatalysts Based On Reduced Graphene Oxide– TiO2 Composites For Degradation Of Diphenhydramine Pharmaceutical And Methyl Orange Dye, Applied Catalysis B: Environmental 123– 124 (2012) 241– 256.
[20]
Yun Hau Ng, Akihide Iwase, Nicholas J. Bell, Akihiko Kudo, Rose Amal, Semiconductor/Reduced Graphene Oxide Nanocomposites Derived From Photocatalytic Reactions, Catalysis Today164 (2011) 353–357.
[21]
Min Shi, Jianfeng Shen, Hongwei Ma, Zhiqiang Li, Xin Lu, Na Li, Mingxin Ye, Preparation Of Graphene– TiO2 composite By Hydrothermal Method From Peroxotitanium Acid And Its Photocatalytic Properties, Colloids And Surfaces A: Physicochem. Eng. Aspects Xxx (2012) Xxx– Xxx.
[22]
Yulin Min, Kan Zhang, Wei Zhao, Fangcai Zheng, Youcun Chen, Yuanguang Zhang, Enhanced Chemical Interaction Between TiO2 and Graphene Oxide For Photocatalytic Decolorization Of Methylene Blue, Chemical Engineering Journal 193-194 (2012) 203–210.
[23]
Bernaurdshaw Neppolian, Andrea Bruno, Claudia L. Bianchi, Muthupandian Ashokkumar, Graphene Oxide Based Pt– TiO2 photocatalyst: Ultrasound Assisted Synthesis, Characterization And Catalytic Efficiency, Ultrasonics Sonochemistry 19 (2012) 9–15.
[24]
Chengyi Houa, Qinghong Zhang, Yaogang Li, Hongzhi Wang, P25–Graphene Hydrogels: Room-Temperature Synthesis And Application For Removal Of Methylene Blue From Aqueous Solution, Journal Of Hazardous Materials 205– 206 (2012) 229– 235.
[25]
Thuy-Duong Nguyen-Phan, Viet Hung Pham, Eun Woo Shin, Hai-Dinh Pham, Sunwook Kim, Jin Suk Chung, Eui Jung Kim, Seung Hyun Hur, The Role Of Graphene Oxide Content On The Adsorption-Enhanced Photocatalysis Of Titanium Dioxide/Graphene Oxide Composites, Chemical Engineering Journal170 (2011) 226–232.
[26]
Donglin Zhao, Guodong Sheng, Changlun Chen, Xiangke Wang, Enhanced Photocatalytic Degradation Of Methylene Blue Under Visible Irradiation On Graphene@ TiO2 Dyade Structure, Applied Catalysis B: Environmental 111– 112 (2012) 303– 308.
[27]
ZHAO Huimin, SU Fang, FAN Xinfei, YU Hongtao, WU Dan, QUAN Xie, Graphene- TiO2 Composite Photocatalyst With Enhanced Photocatalytic Performance, Chin. J. Catal., 2012, 33: 777–782.
[28]
Eunwoo Lee, Jin-Yong Hong, Haeyoung Kang, Jyongsik Jang, Synthesis Of TiO2 nanorod-Decorated Graphene Sheets And Their Highly Efficient Photocatalytic Activities Under Visible-Light Irradiation, Journal Of Hazardous Materials 219– 220 (2012) 13– 18.
[29]
Safety Manual for The Use Of Ultra-Violet Light, School Of Chemistry, University Of Glasgow, 2013.
[30]
Nanping Xu, Zaifeng Shi, Yiqun Fan, Junhang Dong, Jun Shi, And Michael Z.-C. Hu, Effects Of Particle Size Of TiO2 on Photocatalytic Degradation Of Methylene Blue In Aqueous Suspensions, Ind. Eng. Chem. Res. 1999, 38, 373-379.
[31]
Jutaporn Chanathaworn, Charun Bunyakan, Wisitsree Wiyaratn, And Juntima Chungsiriporn, Photocatalytic Decolorization Of Basic Dye By TiO2 Nanoparticle In Photoreactor, Songklanakarin J. Sci. Technol. 34 (2), 203-210, Mar. - Apr. 2012.
[32]
Shizhen Liu, Hongqi Sun, Shaomin Liu, Shaobin Wang, Graphene Facilitated Visible Light Photodegradation Of Methylene Blue Over Titanium Dioxide Photocatalysts, Chemical Engineering Journal 214 (2013) 298–303.
[33]
Satyen Gautam, Sanjay P Kamble, Sudhir B Sawant And Vishwas G Pangarka, Photocatalytic Degradation Of 3-Nitrobenzenesulfonic Acid In Aqueous TiO2 Suspensions, J Chem Technol Biotechnol81:359–364 (2006).
[34]
Jutaporn Chanathaworn, Charun Bunyakan, Wisitsree Wiyaratn And Juntima Chungsiriporn, Photocatalytic Decolorization Of Basic Dye By TiO2 Nanoparticle In Photoreactor, Songklanakarin J. Sci. Technol. 34 (2), 203-210, Mar. - Apr. 2012.
[35]
Chethana Gadiyara, Bhanupriya Boruaha, Calvina Mascarenhasa And Vidya Shetty K, Immobilized Nano TiO2 For Photocatalysis Of Acid Yellow-17 Dye In Fluidized Bed Reactor, International Journal Of Current Engineering And Technology, Special Issue1 (Sept 2013) 84-87.
[36]
Y. M. S. El-Shazly; S. I. M. Ibrahim; And A. H. Konsowa, Removal Of Direct Red 23 Dye By Ozonation In A Batch Bubble Column Reactor, ADEST International Conference (2010).
[37]
Yash Boyjoo, Ming Ang, And Vishnu Pareek, Photocatalytic Treatment Of Shower Water Using A Pilot Scale Reactor, Hindawi Publishing Corporation, International Journal Of Photoenergy, Volume 2012, Article ID 57891.
[38]
K. Kočí, K. Zatloukalová, L. Obalová, S. Krejčíková, Z. Lacný, L. Čapek, A. Hospodková, O. Šolcová, Wavelength Effect On Photocatalytic Reduction Of CO2 By Ag/ TiO2 catalyst, Chin. J. Catal., 2011, 32: 812–815.
[39]
Jamshid Behin, Negin Farhadian, Response surface methodology and artificial neural network modeling of reactive red 33 decolorization by O3/UV in a bubble column reactor, Advances in Environmental Technology 1 (2016) 33-44.
Browse journals by subject